For General Mod and Scooter Discussion and events organised by the Bristol Mod Scooter Club only. All other non-club events to go in the "Gigs and other events" forum.
Hi Chris,scoot starts sweet as first kick, will run perfectly until normal temperature then cut out (about 5 miles). Then no spark at all ! Replaced electronic ignition and regulator , same problem ! Then a mate tested resistance coming out of stator when cold - normal reading , then when warmed up - increased reading so we concluded that the LT coil the stator may be faulty ! So replaced that ! OK for one day then back to original problem - cutting out when engine warm !!
all noted- I'm assuming you've replaced the stator; CDI unit and regulator?
If so its unlikely (but unfortunately not unknown!) that the replaced components are faulty as well, and that the fault therefore lies elsewhere.
It sounds like a heat related problem and my first instinct would be a dry/ duff joint somewhere as it appears to work OK at start up temperature and breaks down when warm/ hot.
Have you considered the actual ignition switch itself?- try bypassing the switch by removing the green wire- this will eliminate any internal switch fault although you will have to stall the scooter to stop it!
Make sure you have good earths where required and check them "electrically" rather than just visually.
Apart from that its a question of working back from the plug and changing components as necessary I'm afraid.
There is a lot to be said for 6v points systems! Please let me know how you get on.
Chris
Lambretta scootering April 1968 to April 2021. Now retired.
thanks for your reply chris, stator and ignition switch renewed last year, and as explained new LT coil on stator, new cdi and regulator, so presuming all ok there, maybe we could get together you could take a look at earths, and test ignition switch etc. i,m on holiday this sat for 10 days, cheers !
Danny no problem with getting together .........BUT am going on holiday early tomorrow. Back 12 August!
Have a go at making sure all the earths are bolted tightly to bright metal. If that doesn't help and no one else can assist (and you can wait), give me a shout on my return- where are you roughly?
Chris
Lambretta scootering April 1968 to April 2021. Now retired.
Cheers Chris, I too am back on 10th so good for both of us, we could meet on the following sat ! I am in kingswood, I think you are in Bradley stoke ? If so I could probably get the scoot to you ( slowly but surely ) ! Have a chat when we return ! Have a nice holiday ! And thanks again !